Product ID:ZRC COLD GALVANIZING COMPOUND (AEROSOL)
MSDS Date:02/27/1992
FSC:8030
NIIN:01-015-1550
MSDS Number: BNTNV

Z R C PRODUCTS CO

21 NEWPORT AVE
QUINCY, MA 02171
US

Emergency Phone: 800-424-9300 CHEMTREC/617-328-6700

Info Phone: 617-328-6700

Preparer: STEVE COLLINS

Cage: MO539

Z R C PRODUCTS CO

QUINCY, MA 02171 US

Telephone: 617-328-6700

Cage: MO539

METHYL ETHYL KETONE (SARA III) (VAPOR PRESSURE 75 MM @ 20C)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 35%

OSHA PEL 200 PPM/300 PPM STEL

ACGIH TLV: 200 PPM/300 PPM STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ZINC (SARA III)

CAS: 7440-66-6

RTECS: ZG8600000

Fraction By Weight: 37.4%

OSHA PEL TWA 50 PPM/15 MG/M3*

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ZINC OXIDE

CAS: 1314-13-2

RTECS: ZH4810000

Fraction By Weight: 1.6%

OSHA PEL 15MG/M3 TDUST/5 FUME

ACGIH TLV: 10MG/M3 TDUST; 9293

XYLENE (SARA III) (VAPOR PRESSURE 6 MM @ 20 C) (LEL 1.0)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 10%

OSHA PEL 100 PPM/150 PPM STEL

ACGIH TLV: 100 PPM/150 PPM STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

VM & P NAPHTHA (VAPOR PRESSURE 2 MM @ 20C) (LEL 0.9)

CAS: 8032-32-4

RTECS: OI6180000

Fraction By Weight: <5%

OSHA PEL 300 PPM/400 STEL

ACGIH TLV: 300 PPM

PROPANE (VAPOR PRESSURE 123 PSIA @ 20C) (LEL 2.3)

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 15%

OSHA PEL 1000 PPM/1800 MG/M3

ACGIH TLV: SMPL ASPHYXIANT

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:PROPANE IS ASPHYXIANT. SOLVENTS IN
MAT'L ARE CENTRAL NERVOUS SYSTEM DEPRESSANTS (DROWSINESS,
DIZZINESS, HEADACHE, SLURRED SPEECH, INTOXICATION
W/EUPHORIA/DEPRESSION, STUPOR, UNCONSCIOUSNESS) INHAL: NO SE,
THROAT, LUNG IRRIT. SKIN: DEFATTING, DERMATITIS. EYE: TEARS,
BURNING, IRRITATION, CONJUNCTIVITIS. **
Explanation of Carcinogenicity:N/K*MOISTR & ACID CONTAM CAN FORM
HYDROGEN GAS, CAUSE CANS TO BULGE. DON'T MOVE, OPEN, PUNCTURE CANS.
CALL 617-328-6700.
Effects of Overexposure:** INGEST: POISONING, MAY BE FATAL; AVOID
ASPIRATION. LUNG CONTACT MAY CAUSE CHEMICAL PNEUMONITIS. EXCESSIVE
INHAL: FUME FEVER, ZINC SHAKES, ETC. REPEAT/PROLONG OVEREXPOSE:
PERMANENT BRAIN, CENTRAL NE RVOUS SYSTEM DAMAGE. MINOR
EMBRYOTOXIC/FETOTOXIC EFFECTS (RATS). MAY CAUSE ALLERGIC SKIN
REACTION.

First Aid:INHAL: REMOVE TO FRESH AIR. KEEP WARM, QUIET. GIVE ARTIF
RESPIRATION IF REQUIRED. GET MED AID. EYES: WASH IMMED WITH LARGE
AMOUNT WATER 15 MIN. TAKE TO PHYSICIAN FOR MED AID. SKIN: WASH
CONTACT AREA P ROMPTLY W/SOAP & WATER. PROMPTLY REMOVEPAINT-WET
CLOTHING. CONSULT PHYSICIAN IF IRRIT PERSISTS. INGEST: DO NOT
INDUCE VOMITING WITHOUT MEDICAL ADVICE. SEE PHYSICIAN, EMERGENCY
ROOM, POISON CTR IMMED.

Flash Point:NR
Lower Limits:0.9 (VOL)
Upper Limits:66.4 (VOL)
Extinguishing Media:CLASS B EXTINGSHR, FOAM, DRY CHEM. DONT USE WTR!
USE FULL PROTECT EQUIP & SCBA IN ENCLOSURES. HIGHLY FLAMM/MOD
EXPLOS
Fire Fighting Procedures:DONT USE WATER IN ANY FORM. WATER MAY BE USED
TO COOL CLSD CNTNRS, BUT TAKE CARE TO PREVENT WATER ACCESS TO WET
PAINT & SPRAY RESIDUES. SEE SPILL SECTION.
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD. ISOLATE FROM HEAT/IGNIT.
APPLIC TO HOT SRFC REQ CAUTION. OVEREXPOS TO DECOMP-HLTH HZD.
HEAVIER THAN AIR, FLOW TO DISTANT IGNIT SOURCE/FLASHBCK*

Spill Release Procedures:LRG: EVAC AREA. ALL SPILLS: ELIMINATE IGNIT
SOURCES. DIKE, CONTAIN W/DRY, INERT MAT'L. ELIMINATE MOISTURE
SOURCES. DONT USE WATER IN CLEANUP OPERATIONS. RECOVER FREE LIQ.
USE ABSORB FOR REST. DONT FLU SH W/WATER. USE NONSPARK TOOLS.
SPILLS-SLIPPERY.

Handling and Storage Precautions:USE NONSPARK TOOLS. VENT USE AREAS.
EXCLUDE IGNIT SOURCE/HEAT. NO SMOKING IN THESE AREAS. PREVENT
ACCUMULATION (SUFF VENT)OF VAPOR IN LOW AREAS/SUMPS.
Other Precautions:MAT'L IS ELECTRICALLY CONDUCTIVE. FLAMM LIQ. STORE IN
COOL, CLEAN DRY, VENTED, FIRE RESISTANT(MEET OSHA REQ) AREA. DONT
STORE IN DIRECT SUNLIGHT. STORE IN CLSD LABELED CANS (LABELS
SPECIFY FLAMMABILIT Y). DONT STORE ABOVE 49C. ***

Respiratory Protection:OUTDOOR/OPEN AREAS: NIOSH/MSHA RSPRTR (FILTER
DUST PARTIC) DURING & AFTER APPLIC (UNLESS BELOW TLV). RESTRICT
VENT: NIOSH/MSHA RSPRTR (COMBINATN ORGANIC VAPOR, DUST PARTIC).
CONFINED: AIR LINE TYPE RS PRTR/HOOD. FOLLOW RSPRTR MFRS DIRECTIONS
Ventilation:WORK PLACE AREAS REQUIRE EXHAUST VENT IN ACCORDANCE W/OSHA
REGULATIONS 29CFR1910.107D TO MAINTAIN LEVELS BELOW TLV.
Protective Gloves:NEOPRENE GLOVES
Eye Protection:SFTY GOGGLES W/UNPERFORATED SIDE SHIELD#
Other Protective Equipment:WEAR NEOPRENE APRONS OVER FITTED
CLOTHES,CHEM RESISTANT BOOTS W/STEEL TOES,PROTECTIVE CREAM,EYEWASH
FOUNTAIN,SFTY SHOWER
Work Hygienic Practices:OBSERVE ALL RULES OF GOOD HYGIENE DURING &
AFTER USE. WASH BEFORE SMOKING OR EATING. WASH/DISCARD CONTAM
CLOTHING.
Supplemental Safety and Health
*** DONT INGEST. DONT PUNCTURE, DRAG OR SLIDE CNTNR. KEEP AWAY FROM
CHILDREN. EMPTY CONTAINERS MAY CONTAIN EXTREMELY FLAMMABLE RESIDUES
AND EXPLODE IF HEATED. #SHOULD BE USED
WHERE SPLASHING INTO EYES IS POSSIBLE

HCC:V3
Boiling Pt:B.P. Text:-42 TO 144C
Vapor Pres:50 @ 21C
Vapor Density:> AIR
Spec Gravity:1.14 @ 25C
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:INSIGNIFICANT
Appearance and Odor:GREY LIQ W/ODOR TYPICAL OF ALIPHATIC & AROMATIC
HYDROCARBONS MIXED W/KETONE.
Percent Volatiles by Volume:59(WT)

Stability Indicator/Materials to Avoid:YES
MAY REACT VIOLENTLY W/STRONG OXIDIZING AGENTS SUCH AS CHLORINE, OXYGEN,
WATER, WEAK OR CONCENTRATED ACIDS.
Stability Condition to Avoid:STORE IN DRY AREAS AWAY FROM OXIDIZING
AGENTS, ACIDS, ALKALIES, & WATER. AVOID DUSTING & ACCUMULATION OF
SPRAY RESIDUES.
Hazardous Decomposition Products:HYDROGEN GAS ACCOMPANIED W/ADDED RISK
OF EXPLOSION/FIRE. FUMES OF ZINC OXIDES, OXIDES OF CARBON &
NITROGEN.
Conditions to Avoid Polymerization:SENSITIVITY TO IMPACT: IMPACT
W/SPARKING MAY PRODUCE DISCHARGE OF CONTENTS WITH FIRE OR EXPLOSION
HAZARD.

Waste Disposal Methods:DISPOSE OF ABSORBED MAT'L/FREE WASTE LIQ IN DRY
CNTNRS ACCORDING TO LOCAL, STATE & FED REGS. DISPOSE OF MAT'LS
INCLUDING EMPTY CANS ACCORDING TO FED, STATE & LOCAL REGS. DONT
INCINERATE. DONT FLUSH IN TO SEWERS. CNTNRS MAY EXPLOD W/HEAT (EVEN
EMPTY).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.